Electrical Issues - Chevy SSR Forum
 5Likes
  • 1 Post By soren703
  • 1 Post By Dragon2U
  • 1 Post By nj6969
  • 2 Post By Autoprof
 
LinkBack Thread Tools Display Modes
post #1 of 6 (permalink) Old 04-26-2019, 04:16 AM Thread Starter
Member
 
ksamson23's Avatar
 
Join Date: Jan 2017
Location: Kennesaw GA
Posts: 7


My SSR:
Orange and Silver 2006
Electrical Issues

Hello all, I have had the dreaded SSR electrical failure. 2006 SSR, 82K miles.

Problem: Driving 20 mins experience a complete eng. shut off.

Try the re-start and the starter stays engaged.

Sits for 4 hrs starts up.

OBDII codes:
P0443
P0689
P1516
P1682
P2101
P0443

I researched the codes, multiple faults identified. Just want to start in the most logical, cheapest place.

Help. Please.
ksamson23 is offline  
Sponsored Links
Advertisement
 
post #2 of 6 (permalink) Old 04-26-2019, 04:41 AM
SSR Pit Crew
Lifetime Supporting Member
 
soren703's Avatar
 
Join Date: Feb 2013
Location: Ocoee, FL
Posts: 526


My SSR:
2005 Silver/Gray
Garage
You need to have the fuse box repaired. There is a broken wire that separates enough when engine is warm to shut down engine usually takes about 20 minutes for it to cool down enough to restart. There are several guys that will do the repair for you I am sure they will respond.
ksamson23 likes this.
soren703 is offline  
post #3 of 6 (permalink) Old 04-26-2019, 05:18 AM Thread Starter
Member
 
ksamson23's Avatar
 
Join Date: Jan 2017
Location: Kennesaw GA
Posts: 7


My SSR:
Orange and Silver 2006
Awesome, thank you Sir,
ksamson23 is offline  
Sponsored Links
Advertisement
 
post #4 of 6 (permalink) Old 04-26-2019, 06:02 AM
Super Road Rocket Pilot
Lifetime Supporting Member
 
Dragon2U's Avatar
 
Join Date: Jul 2005
Location: Georgia
Posts: 5,644


My SSR:
Empty Garage - Previous 03 04 05 owner - on hunt for next one ;)
Quote:
Originally Posted by ksamson23 View Post
Awesome, thank you Sir,
Always a lot of help here, soren703 and a few others in FL do a ton of work on the Rs.

Not sure where you are but I am in GA and repair them, there are people in FL as mentioned above that do it as well as in AZ and I think CA. Send me a PM with your email address for more info if you have questions.
Autoprof likes this.

Add your location on Fanatic PINMAP and locate others
To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.



To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.
Dragon2U is offline  
post #5 of 6 (permalink) Old 04-26-2019, 07:48 AM
SSR Pit Crew
Lifetime Supporting Member
 
nj6969's Avatar
 
Join Date: Jun 2014
Location: Forney tx
Posts: 2,973


My SSR:
2006 #107 of 199 Smokin Asphalt FPR's bought 6-18-2014; Kathy's '04 Ultra Violet Bought 2-1-'17
Garage
ksamson24,----Consider going to "Tools" in the red banner, click on "User CP" go to "Your Profile" then click "Edit Your Details". Then, whenever you "post" something, it will show in the left column under your name, like the rest of us, and we will know where you are and what you drive. Then if you have a problem, someone close by might be able to help out.

--Also if you haven't yet, go to "FORUMS", "SSRFanatics News & Polls", click "New Member section", click "Post New Thread" and introduce Yourself!!

And, if you decide on a "Lifetime or Premium" Membership, you will get more benefits and no ads!? and show appreciation for tips and help. Click "Get Premium" under the Red Banner, read and compare the Advantages!!

Nick
Auggie Doggie likes this.


To view links or images in signatures your post count must be 10 or greater. You currently have 0 posts.

Nick '06 Smokin Asphalt FPR & Kathy '04 Ultra Violet
nj6969 is offline  
post #6 of 6 (permalink) Old 04-26-2019, 09:21 AM
SSR Pit Crew
Supporting Member
 
Autoprof's Avatar
 
Join Date: Sep 2011
Location: Hilliard Ohio
Posts: 1,490


My SSR:
04 Redline #9973
I will agree with others that suggest the fuse box is at fault

the statement below is complied from a previous post that had same type of symptoms and similar DTCs

I believe fuse box is the issue because relay 42 shuts down with a bad wire in the fuse box. This is the PCM/ECM power relay. That ground circuit is turned on and off by the ECM. P0689 is detecting a problem with the PCM/ECM relay. The ECM monitors the switched side of the relay. It sets based on 0 volts from the "switched" side of the relay.

See the attached document compiled from Service manual regarding the codes that were reset.

This is the second case where the owner has listed these codes and had a "shut down when hot" issue.

Hopefully we hear back from this member, or the member of this previous post that the fuse box fix did indeed solve the problem. While I am 90% sure it is based on these codes - a confirmed fix would increase that to 100%

https://www.ssrfanatic.com/forum/f5/...-start-250109/
Attached Thumbnails
Click image for larger version

Name:	05 intermittent no start codes_Page_1.jpg
Views:	14
Size:	149.2 KB
ID:	546377  
BlueStreak and nj6969 like this.
Autoprof is online now  
Sponsored Links
Advertisement
 
Reply

  Chevy SSR Forum > SSR Discussion > SSR Technical Discussion

Quick Reply
Message:
Options

Register Now



In order to be able to post messages on the Chevy SSR Forum forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in











Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Thread Tools
Show Printable Version Show Printable Version
Email this Page Email this Page
Display Modes
Linear Mode Linear Mode



Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

 
For the best viewing experience please update your browser to Google Chrome